If the walk in cooler is freezing up the first step is to melt ice off the evaporator and then check that the evaporation fan is running and rotating correctly.
Walk in cooler compressor not running.
All you need is your existing cooler a coolbot and an air conditioner.
I found that the unit had a tripped head pressure controller and a condenser fan motor that w.
This was a service call on walk in freezer that wasn t cooling.
Walk in freezer everything runs ok only its not blowing cold air inside the box the lowside of the compressor reading is 10psi and the amps on each lead shows 2 2 amps what is it that my lowside pressure is so low please let me know what i should look for to fix this problem i have been working on the freezer for week still at first nothing was running at all slowly one by one everything.
Next check for a clean coil and clear drain line.
Walk in cooler and freezer problems like compressor failure and failure to maintain pressure can result in costly loss of products inside the cooler.
Sometimes called the controller this device is used to energize the compressor start windings until the unit is running and it usually contains the overload protection component as well.
If the freezer has electrical power the inside light turns on but the compressor won t run a failed cold control thermostat could be the problem.
Because this is a cooler and not a freezer it is set to defrost by simply shutting off the compressor four times per day while still running the evaporator fans.
It is also a big energy user but is rarely even thought of until an issue happens.
When it senses that the compressor must run to keep the refrigerator cool it sends voltage to the compressor and fans.
The electronic control board also receives signals from temperature sensors to monitor the temperatures inside the refrigerator and freezer.
Also check all gauges to be sure temperatures subcooling superheat and pressures are all normal.
If your freezer won t start one of the most common parts to fail is the compressor start relay.
The video below takes you step by step through exactly how to convert your walk in cooler into a coolbot refrigeration system in about 30 minutes.
With this information the electronic control board controls the defrost cycle.
If your freezer has electronic controls instead of a dial a failed relay on the electronic control board or a bad control panel can prevent the compressor from getting power.
